Volkswagen Crafter is currently available in various body styles: minibus, light truck and cargo van. Years of production of the 1st generation: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016. During this period, the car underwent restyling. Since 2017, the second generation of the updated Volkswagen Crafter has been supplied to the markets. In this article you will find a description of the fuse and relay blocks of the Volkswagen Crafter, diagrams and photos of the blocks, as well as their location. Let’s highlight the fuse responsible for the cigarette lighter.
Depending on your vehicle’s trim level (Standard, HighLine, etc.) and year of manufacture, different versions of fuse blocks and relays are possible.
Block arrangement Volkswagen Crafter
The Volkswagen Crafter has the following units:
- Power supply fuse, cl. 30 -S190-
- Fuse block A on the battery -SA-
- Fuse block B on the left pillar -SB-
- Fuse and relay block C near the left pillar -SC-
- Fuse and relay block D under driver’s seat -SD-
- Additional fuses under the driver’s seat
Power supply fuse, class 30
The main power supply fuse, terminal 30, is located in the wiring harness between the generator and the starter.
Fuse block on the battery Volkswagen Crafter
The fuse block in the form of fuse links is located near the battery in the footwell on the left side of the vehicle.
Scheme
Description
| 1 | 80A Glow plug control unit |
| 2 | 40/60/ 80A Radiator fan control unit, Radiator fan |
| 3 | 80A On-board network control unit, Engine electronic components power supply relay Fuse block C |
| 4 | 150A Second battery, Main fuse of additional equipment Fuse block D |
| 5 | 150A Power supply relay terminal 15, Horn relay, Onboard electrical system control unit Fuse block B or Fuse block C |
| 6 | Unloading relay cl. 15, Power supply relay 1 Windshield heating fuse Fuse block D |
| 7 | 150A Auxiliary air heater heating element |
Block near the left post Volkswagen Crafter
It is located on the left in the footwell under the dashboard and consists of 2 blocks: Fuse Block B and Fuse and Relay Block C.
Fuse block B
Scheme
Marking
| 1 | 25A driver’s door control unit |
| 2 | 10A Diagnostic connector (T16/16) |
| 3 | 25A ABS control unit |
| 4 | 40A ABS control unit |
| 5 | Reserve |
| 6 | Reserve |
| 7 | 30A headlight washer pump |
| 8 | 15A relay 1 anti-theft alarm |
| 9 | Reserve |
| 10 | 15A control unit with display of the radio and navigation system |
| 11 | 7.5A control unit for mobile phone control electronics, tachograph control unit |
| 12 | 30A heating switch and heating power change, supply air fan relay |
| 13 | 7.5A autonomous heater timer |
| 14 | 30A driver’s seat heating control, front passenger’s seat heating control |
| 15 | 10A cargo platform lighting switch |
| 16 | 10A heating switch and heating power change, air conditioning control unit, CD changer |
| 17 | 10A interior light switch |
| 18 | Reserve |
Fuse and relay block C
Photo – example
Scheme
Appointment
Relay
- Horn relay
- Switches relay 2 of the wiper motor
- Fuel pump relay
- Switches relay 1 of the wiper motor
- Power supply relay, cl. 50
- Power supply relay terminal 15
- Power supply relay for electronic engine components
- Relay 2 power supply, terminal 15
Fuses
| 1 | 15A High-pitched signal |
| 2 | 25A Electronic ignition lock Control unit for electric steering column lock |
| 3 | 10A Electronic ignition lock Instrument cluster control unit Engine control unit (from May 2012) |
| 4 | 5A Lighting Switch Front Panel Central Control Panel |
| 5 | 30A Wiper motor |
| 6 | 15A Fuel priming pump |
| 7 | 5A Steering column control unit |
| 8 | 20A Engine control unit |
| 9 | 20/25A Fuse 6 in fuse block B (November 2008 to May 2009) Fuse block D (May 2009 to November 2013) |
| 10 | 10A Air flow meter (from May 2012) Reductant level evaluation module (from May 2012) Crankcase ventilation heating resistor (from May 2012) Fuel pressure regulator EGR radiator switching valve (from May 2012) Reductant supply check valve (from May 2012) EGR radiator pump (from May 2012) Reductant pump (from May 2012) |
| 11 | 15A Unloading relay 2 terminals 15 (only for vehicles in the weight class 3.8 t) Fuse 1 in fuse block D Fuse 2 in fuse block D |
| 12 | 10A Airbag control unit |
| 13 | 15A Luggage compartment light switch Cigarette lighter |
| 14 | 5A Lighting switch Instrument cluster control unit Diagnostic connector |
| 15 | 5A Heater and operating mode selector switch Headlight leveling control Left and right headlight leveling actuator motor |
| 16 | 10A Stop-start system main switch Transmission neutral position switch Oil level and temperature sensor Fuel pump relay Coolant pump relay after engine shutdown Glow plug control unit Power supply relay, cl. 50 Starter relay 1 (from November 2013) Starter relay 2 (from November 2013) Boost pressure limit solenoid valve Lambda probe heating element Exhaust gas recirculation system radiator switch Fuel metering valve Exhaust gas flap valve (from November 2013) Coolant circulation circuit valve |
| 17 | 10A Airbag control unit |
| 18 | 7.5A Brake light switch (from July 2006 to November 2011) Brake pedal limit switch -F63- (from July 2006 to November 2011) Unloading relay, terminal 15 Voltage stabilizer (from November 2011) Special body relay, terminal 15 (from November 2011) Unloading relay 3 for terminal 15 (from November 2011) |
| 19 | 7.5A On-board network control unit (interior lighting) |
| 20 | 25A On-board network control unit |
| 21 | 5A Air flow meter Engine control unit |
| 22 | 5A Brake light switch (until June 2006) Brake pedal limit switch (until June 2006) Lateral acceleration sensor (from July 2006) Longitudinal acceleration sensor (from July 2006) ABS control unit (from July 2006) |
| 23 | 25A Starter On-board network control unit |
| 24 | 10A Reserve, terminal -15- Battery regulation system control unit (since May 2013) |
| 25 | 30A 12V Socket |
Fuse number 13 at 15A is responsible for the cigarette lighter.
Fuse and relay block D under the driver’s seat Volkswagen Crafter
Option 1
Models released before 05.2011.
Photo
Transcript
Relay
- Relay of special super-boosts, class 15
- Relay of special super-boosts, class 61
- Interior lighting relay, Tipping device relay (until October 2007), Tailgate relay
- Headlight cleaning system relay
- Flashing beacon relay
- Anti-theft alarm relay 1
- Cooling system pump relay
- Coolant pump relay after engine shut-off
- Siren relay
- Not used
Fuses
| 1 | 5A Driver’s door power window control panel Rear window heating relay (until June 2006) Rear window heating relay 2 (from July 2006)< /span> |
| 2 | 30A Rear window wiper motor in the door |
| 3 | 5A Timer Transmission neutral switch Display control unit Mobile phone control electronics control unit (until May 2011) Rear view camera |
| 4 | 7.5A Switch for adjusting the operating speed (from July 2006) Power take-off control sensor (from July 2006) Rear window heating relay (until June 2006) Trailer recognition control unit Tachograph control unit (from July 2006) |
| 5 | 5/10A Selector Fur control unit. Electronically controlled gearbox |
| 6 | 5A Battery regulation system control unit (until May 2013) Crankcase ventilation system heating resistor |
| 7 | 10A Fuel filter heating element |
| 8 | 5/10A Tipping device button Special body relay, cl. 15 Connector, 6-pin (from May 2007) Connector, 7-pin (tailgate connection block) |
| 9 | 15A Roof fan switch for cargo compartment ventilation, Siren relay |
| 10 | 25A For the manufacturer of superstructures and special equipment |
| 11 | 15A Relay for special overhead buoys, class 15 |
| 12 | 10A Relay for special overhead buoys, class 61 |
| 13 | 10/30A Evaporator fan control unit (from May 2007 to May 2011) Roof turn signal repeater relay (until May 2007) |
| 14 | 20A Trailer recognition control unit (until August 2006) Connector, 9-pin (preparation for post-factory installation of TSU from September 2006) TSU socket (from September 2006) |
| 15 | 25A Trailer recognition control unit |
| 16 | 7.5A Parking assistant control unit Tire pressure monitoring system control unit |
| 17 | 25A Control unit for programmable special functions |
| 18 | 25A Control unit for programmable special functions |
| 19 | 5/25A Roof electrical control unit |
| 20 | 7.5/10A Coolant pump relay after engine shut-off Entrance and footwell lighting relay (from May 2009) |
| 21 | 15/30A Rear window heating relay |
| 22 | 15A Rear window heating relay (until June 2006) Rear window heating relay 2 |
| 23 | 10/15A Cargo platform lighting switch (from November 2008) 12 V socket 2 |
| 24 | 15A 12V socket 4 |
| 25 | 15A 12V socket 3 |
| 26 | 25A Auxiliary heater control unit |
| 27 | 20/25A Auxiliary heater control unit |
| 28 | 30/40A Evaporator fan control unit (until April 2007) Transmission hydraulic pump relay (since May 2007) |
| 29 | 15A Fur control unit. Electronically controlled gearbox |
| 30 | 40A Transmission hydraulic pump relay (until April 2007) Battery regulation control unit |
| 31 | 15/30A Rear supply fan control unit Left sliding door control unit Rear supply fan |
| 32 | 5A Control unit for battery monitoring |
| 33 | 15A Right sliding door control unit |
| 34 | 15A Reductant heating system control unit (since April 2009) |
| 35 | 3/15A Reductant heating system control unit (since April 2009) |
| 36 | Not used |
Option 2
Description
| 1 | 5A Power window control panel in the driver’s door Rear window heating relay 2 |
| 2 | 30A Rear window wiper motor in the door |
| 3 | 5A Timer Neutral switch Gearbox Display panel Rear view camera |
| 4 | 7.5A Switch for adjusting operating speed PTO control sensor Trailer recognition control unit Tachograph control unit |
| 5 | 5/10A Selector Fur control unit. Electronically controlled gearbox Hood limit switch (from November 2011) |
| 6 | 5/10A Crankcase ventilation system heating resistor Battery regulation system control unit (from May 2011 to May 2013) |
| 7 | 10A Fuel filter heating element |
| 8 | 5/10A Tipping device button Parking assistant control unit (from May 2013) Special body relay, cl. 15 (until November 2011) Connector, 6-pin -T6ah- Connector, 7-pin -T7f- (tailgate connection block) |
| 9 | 15A Roof fan switch for cargo compartment supply ventilation (until November 2011) Siren relay (until November 2011) Not used (since November 2011) |
| 10 | 25A For the manufacturer of superstructures and special equipment |
| 11 | 15A Relay for special overhead buoys, class 15 |
| 12 | 10A Relay for special overhead buoys, class 61 |
| 13 | Reserve |
| 14 | 20A Connector, 9-pin -T9b- (preparation for aftermarket TSU installation) TSU socket |
| 15 | 25A Trailer recognition control unit |
| 16 | 7.5A Parking assistant control unit Tire pressure monitoring system control unit |
| 17 | 25A Control unit for programmable special functions |
| 18 | 25A Control unit for programmable special functions |
| 19 | 5/25A Roof electrical control unit |
| 20 | 7.5/10A Coolant pump relay after engine shut-off Entrance and footwell lighting relay |
| 21 | 30A Rear window heating relay |
| 22 | 15A Relay 2 rear window heater |
| 23 | 10/15A Cargo platform lighting switch 12 V socket 2 -U18- |
| 24 | 15A 12V socket 4 |
| 25 | 15A 12V socket 3 |
| 26 | 25A Auxiliary heater control unit |
| 27 | 20/25A Auxiliary heater control unit |
| 28 | 30/40A Transmission hydraulic pump relay, Starter relay 1 |
| 29 | 15A Fur control unit. Electronically controlled gearbox |
| 30 | 5A Battery regulation system control unit |
| 31 | 15/30A Left sliding door control unit (from May 2012) Rear supply fan control unit Rear supply fan |
| 32 | 5A Control unit for battery monitoring |
| 33 | 7.5/15/30A Not used Right sliding door control unit (since May 2012) Transfer case lock relay (since January 2012) Air compressor (since January 2012) |
| 34 | 7.5/15A Reductant heating system control unit Gearbox sensor for differential lock |
| 35 | 3/15A Reductant heating system control unit Air compressor protection control unit (since January 2012) |
| 36 | 5A Not used (until January 2012) Air compressor switch (since January 2012) |
| 37 | Reserve |
| 38 | Reserve |
| 39 | 7.5/15A Roof fan switch for cargo compartment supply ventilation (from November 2011) Siren relay (from November 2011) |
| 40 | Reserve |
| 41 | Reserve |
| 42 | 30A Evaporator fan control unit -J349- |
| 43 | Reserve |
| 44 | Reserve |
| 45 | Reserve |
| 46 | Reserve |
| 47 | Reserve |
| 48 | Reserve |
| 49 | Reserve |
| 50 | Reserve |
| 51 | Reserve |
| 52 | Reserve |
| 53 | Reserve |
| 54 | Reserve |
| 55 | Reserve |
| 56 | Reserve |
Relay block Volkswagen Crafter
An additional block with fuses and relays can be mounted under the seat itself.
Appointment
| A | Battery relay |
| B | Starter relay 1 |
| C | Starter relay 2 |
| 1 | Not used |
| 2 | Unloading relay cl. 15 |
| 3 | Unloading relay 3 terminals 15 Air compressor relay |
| 4 | Transmission hydraulic pump relay Daytime running light relay that turns on |
| 5 | Rear window heating relay |
| 6 | Rear window heating relay 2 |
| 7 | Unloading relay 2 terminals 15 |
| 8 | Not used |
| 9 | Windshield heating relay |
| 10 | Supply fan relay |
| 11 | Not used |
| 12 | Not used |
| 13 | Not used |
| 14 | Not used |
| 15 | Relay of special super-boosts, class 15 |
| 16 | Relay of special super-boosts, class 61 |
| 17 | Tailgate relay Interior lighting relay |
| 18 | Headlight cleaning system relay Air compressor unlocking relay |
| 19 | Relay 2 sirens Relay for entrance and footwell lighting Relay for air compressor – regeneration |
| 20 | Anti-theft alarm relay 1 |
| 21 | Cooling system pump relay |
| 22 | Coolant pump relay after engine shut-off |
| 23 | Siren relay ABS disconnect relay |
| 24 | Relay lock 1 transfer box |
| 25 | Relay lockout 2 transfer box |
| 26 | Reverse warning device disconnect relay Transfer case 3 lockout relay |
Volkswagen Crafter fuses and relays. Volkswagen Crafter fuse diagram.