Fuse box diagram (fuse location), location and purpose of fuses and relays Iveco Daily V / Mk5 (2011, 2012, 2013, 2014).
Checking and replacing fuses
A fuse is a safety feature of an electrical system. A fuse will trip (i.e., blow) if there is a fault or improper intervention in the electrical system.
If an electrical device does not work, check to see if the corresponding fuse is blown. Look at the silver strip inside the fuse. If the strip is broken or melted, replace the fuse. First check the fuses that protect the failed component, but check all the fuses before deciding that the blown fuse is not the cause. Replace any blown fuses with others of the same amperage (same color) and check the operation of the component.
Notification
- Before replacing a fuse, make sure the ignition key is removed and all other electrical devices are turned off/disconnected.
- Never replace a broken fuse with anything other than a new fuse. Always use fuses of the same color.
- Never change the fuse to a different amperage. This may cause damage to the electrical system and fire.
- If the fuse blows again, have the vehicle checked by a qualified service center.
Cabin Fuse Box Diagram
The fuse panel is located behind the cover on the left side of the instrument panel.
| No. | Function | A |
|---|---|---|
| F12 | Relay T1b (30-87) right low beam headlight | 7.5 |
| F13 | Relay T1a (30-87) left low beam headlight – headlight regulator | 7.5 |
| F31 | Relay T54 (86) headlight washers and T50 – T51 – T52 – T53 – eln electric motors and window lifter controls | 5 |
| F32 | Relay T44 (30-86) for removing the battery with minimum voltage – interior lighting | 7.5 |
| F33 | Swinging door | 15 |
| F34 | Plumber’s socket | 20 |
| F36 | Relay T20 car radio MODUS – tachograph – convergence – siren – parking sensor | 15 |
| F37 | Instrument panel – brake lights – trailer socket | 7.5 |
| F38 | Central lock | 20 |
| F42 | ABS9 or ESP9 | 5 |
| F43 | Relay T23a (86-87) for windshield washer and relay T23b (86-87) | 20 |
| F47 | Relay T25a (86-87) and T25b (86-87) driver’s side window lift | 25 |
| F48 | Relay T26a (86-87) and T26b (86-87) passenger side window lift | 25 |
| F49 | Control panel – tachograph – add. module – mounting socket – ASR control – Telma (coil) – video camera – rocking – rear differential lock | 5 |
| F50 | Airbag | 5 |
| F51 | Green filter – car radio – toe-in – parking sensors -CAF | 5 |
| F53 | Instrument panel – additional heater timer | 5 |
| F89 | IN STOCK | — |
| F90 | Relay T11a (30-86) left high beam headlight | 7.5 |
| F91 | Relay T11b (30-86) right high beam headlight | 7.5 |
| F92 | Relay T12a (30-86) left fog lamp | 7.5 |
| F93 | Relay T12b (30-86) right fog lamp | 7.5 |
| Relay | ||
| T01a | Left low beam headlight – headlight adjuster | |
| T01b | Right low beam headlight | |
| T11a | Left high beam headlight | |
| T11b | Right high beam headlight | |
| T12a | Left fog light | |
| T12b | Right fog light | |
| T23a | Windshield washer | |
| T25a | Driver’s side window lift UP | |
| T25b | Driver’s side window DOWN | |
| T26a | Passenger side window lift UP | |
| T26b | Passenger side window DOWN | |
| T37a | Central locking of rear doors | |
| T37b | Central closure (general) | |
| T37s | Central closing of side doors | |
| T37d | Central locking of the rear door | |
| T44 | Battery Removal at Minimum Voltage | |
Fuse box above the battery
| No. | Function | A |
|---|---|---|
| 1 | +30 plus from F75 for starter, generator and retarder (if equipped) | 500 |
| 2 | +30 plus from F70 for SCM BUS-BAR | 150 |
| 3 | +30 plus from F73 for preheating glow plugs | 60 |
| 4 | +30 plus from F72 for brake unit | 40 |
| 5 | +30 plus from F71 for power supply of 1st on-board computer | 80 |
| 6 | +30 plus to F64 in SCM/A for IBS sensor for Stop & Start | — |
Engine Compartment Fuse Box Diagram
| No. | Function | A |
|---|---|---|
| F01 | Air suspensions | 40 |
| F02 | Ignition switch | 30 |
| F03 | Cabin climate control fans and additional engine coolant heater | 40 |
| F04 | Brake system (valves) | 30 |
| F05 | Air suspensions | 40 |
| F06 | SCM 1 / A – SCM 1 / B – Power Supply SCM2 | 40 |
| F07 | Relay T7 (30-87) for power discharge from the ignition switch | 40 |
| F08 | Relay T8 (30-87) fuel pump | 15 |
| F09 | Automatic transmission | 30 |
| F11 | Relay T64 (30-87) for heated outside mirrors and heated windshield | 15 |
| F11 | EDC FI A (primary loads) from MAIN RELAY injectors (CNG) | 15 |
| F14 | Automatic transmission – MAIN RELAY T9 (86) | 10 |
| F15 | Relay T2 (30-87) for cooling pump BOSCH | 10 |
| F16 | Cigarette lighter from T7 | 15 |
| F17 | EDC FIC (Secondary Loads) from MAIN RELAY Smart Drive Unit (CNG) | 10/15 |
| F18 | Rear differential lock | 30 |
| F19 | Relay T6 (30-87) for sound signal | 7.5 |
| F20 | 13-pin connector | 10 |
| F21 | Relay TI4 (30) for cylinder solenoid valves (CNG) | 7.5 |
| F22 | EDC F1A and F1C (primary loads) from MAIN RELAY – lambda probe | 20 |
| F22 | Waste gate (CNG) – Lambda probes (CNG) | 15 |
| F23 | Relay T19 (30-87) for wipers | 30 |
| F24 | Socket from T7 | 15 |
| F30 | Relay T3 (30-87) for side marker lights | 7.5 |
| F81 | Automatic transmission | 30 |
| F82 | Body computer 2nd power | 70 |
| F83 | Relay T30 (30-87) heating fans in the cabin | 40 |
| F84 | Cylinder power supply solenoid valve | 15 |
| F84 | Relays T5 and T14 for Baruffaldi coupling | 7.5 |
| F85 | Relay T31 (30-87) fuel filter and sump filter heater | 25 |
| F87 | EDC – Automatic Transmission | 7.5 |
| F87 | 5SF — Automatic transmission | 7.5 |
| Relay | ||
| T02 | Cooling pump BOSCH | 20 |
| T02 | Baruffaldi coupling from trinary (CNG) | 20 |
| T03 | Side marker lights | 30 |
| T05 | Baruffaldi 1st gear clutch | 30 |
| T06 | Horn | 20 |
| T07 | Discharging the ignition switch | 50 |
| T08 | Fuel pump | 20 |
| T09 | MAIN RELAY | 30 |
| T10 | Preventing the engine from starting | 30 |
| T14 | Baruffaldi 2nd gear clutch | 20 |
| T14 | Cylinder solenoid valves (CNG) | 20 |
| T17 | Windscreen wiper 1st or 2nd speed | 10/20 |
| T19 | Indscreen wiper speed activation | 10/20 |
| T20 | Diagnostics with MODUS | 20 |
| T30 | Cabin heating fans | 50 |
| T31 | Fuel filter heater and sediment filter | 30 |
| SCM1/A | ||
| F60 | Additional climate control | 30 |
| F61 | Relay T51 (30-87) air conditioning compressor | 7.5 |
| F62 | Relay T52 (30-87) right rear window heating | 10 |
| F63 | Blowing rear left glass with heating – independent heater – relay T56 (86) compressor | 10 |
| F64 | IBS sensor for stop and start | 5 |
| F65 | Relay T7 (30-87) seat heating | 20 |
| Relay | ||
| T49 | Stop and start | 30 |
| T50 | IN STOCK | — |
| T51 | Activating the compressor from the climate control | 20 |
| T52 | Rear window heating | 20 |
| SCM1/B | ||
| F66 | Relay T54 (30-87) headlight washers | 15 |
| F67 | IN STOCK | — |
| F68 | IN STOCK | — |
| F69 | Additional 4448 for bus | 5 |
| F77 | IN STOCK | — |
| F78 | IN STOCK | — |
| Relay | ||
| T53 | Unit heater | 20 |
| T54 | Headlight washers | 20 |
| T55 | Power take-off | 10/20 |
| T56 | Brake lights with retarder TELMA | 10/20 |
| SCM2 | ||
| T63 | IN STOCK | — |
| T64 | Heated exterior mirrors – heated windshield | 20 |
Iveco Daily V (2011-2014) fuses and relays. Iveco Daily V (2011-2014) fuse diagram.